How can I make my M54 engine faster?

Published by Charlie Davidson on

How can I make my M54 engine faster?

M54 Forced Induction Turbos and superchargers are among the best mods for any engine to increase horsepower and torque. However, boost puts a lot of stress on the engine. You can find M54 turbo or supercharger kits around $4,000 to $8,000. These mods will often boost the M54 into the 300-400+ horsepower range.

What car has the m54b30 engine?

BMW
The BMW M56 SULEV engine (sold in several states of the United States) is based on the M54. The M54 was phased out following the introduction of the BMW N52 engine in 2004. From 2001 to 2003, the M54 was included on the Ward’s 10 Best Engines list….BMW M54.

BMW M54 engine
Predecessor BMW M52
Successor BMW N52

How much boost can M54 handle?

The correct answer is ZERO psi. You can not add any amount of boost and expect any sort of reliability from the car if you are expecting the stock DME to adapt. You will need a tune at a minimum, possibly injectors.

How can I improve my BMW E46 performance?

These are some of the best upgrades you can make to your E46 325i to improve your driving experience and add some excitement.

  1. Shark Injector. The first improvement you should make to your E46 325i is a Shark Injector unit.
  2. Short Shift Kit.
  3. BavAuto Ignition.
  4. Single-Mass Flywheel.
  5. Coilovers.
  6. Sway Bars.
  7. Wheels.
  8. Brake Upgrades.

How long can a M54 engine last?

Now this is nothing to fret about, as they should be lasting anywhere from 60k-100k miles. If you notice your car running hot, running out of coolant, take it in and have the pump checked.

Are M54 engines reliable?

The M54 is the most reliable BMW engine ever built. Here’s why: The camshaft chain drive and the V-belt drive are maintenance-free and designed for the life of the engine. Valve clearances are kept consistent throughout the entire running life of the engine by a self-adjusting hydraulic valve clearance mechanism.

Is the S54 reliable?

The BMW S54 engine is no exception. Expect to replace the S54 water pump every 100,000 miles. Though, failures are not uncommon as early as 60,000 miles. On the other hand, some lucky water pumps may last 120,000+ miles.

Does M54 have forged internals?

No.. the pistons on your M54B30 engine are cast. The connecting rods and the crankshaft are forged though.

Are 330Ci fast?

according to Car and Driver, the 5-sp manual 330Ci coupe does 0 – 60 in 5.8 s, 1/4 mile in 14.4 s.

How long can a 330ci engine last?

Keep the servicing up to spec, do interim oil and filter changes, don’t drive it like you stole it (that’s gonna trash any car), and with any luck you could be fine for years. They have a “design life” of 300,000 miles.

How did BMW make the M54B30 engine?

The tuning was done by Ed Senf who is well know for tuning race BMW engines.. The side of the M54 head is angled so we had to make a custom adapter to use the intake system we wanted. We used a FARO arm to take all the measurements we could and then constructed a 3D model of the intake face of the head.

Is the BMW M54 a good performance engine?

The M54 is an excellent engine, but it’s not an all out straight-line high performance engine. If you’re looking for a lot more out of your M54 you may consider an engine swap or a platform better suited to high horsepower. Nonetheless, those dead set on the M54 should consider the following mods:

What kind of camshaft do I need for BMW M54B30?

Schrick 264/248 camshafts with 10.5/10 mm lift will be a perfect choice to increase the level of HP. You will additionally need cold air intake and performance exhaust system taken from Supersprint, for example. When tuning of ECU is over, your engine will have from 260 to 270 HP.

Which is the best injector software for an M54 engine?

Conforti Shark Injector Performance Software is a popular choice for the E46 330i and 330ci models with the 3.0L M54. Active Autowerke also makes an excellent tuning option. These tunes will work on just about any M54 engine. The previous link for AA tunes is for the M54 325i and 330i.

Categories: Blog